That must be at a specific angle. Be sure to search the forum before you attempt to adjust there.BTW. What`s the another adjustment in the engine end of the cable ? When it is needed to adjust ?
Follow along with the video below to see how to install our site as a web app on your home screen.
Note: This feature may not be available in some browsers.
That must be at a specific angle. Be sure to search the forum before you attempt to adjust there.BTW. What`s the another adjustment in the engine end of the cable ? When it is needed to adjust ?
Proper basic adjustment transformed my clutch/gearchange operation and restored full available adjustment at the hand lever end. Have a look at the manual.
And that is why experienced people change every oil at the first service.Diff bike Diff year (21 V85tt here), but new i had gbox whine and 'clunky' changes inc 1st.
manual says gbox & diff oil doesn't need a chk until 30k km's
my bike (diff to other pics I have seen) has a "bung plug" with hex on side of gearbox. It was done up by the factory gorilla & took impact driver to loosen.
Anyhow I drained engine oil & gbox oil at 600km's & was 600ml of 'sludge' gooy stuff. Def not 'synthetic' (as expected) and wasn't really "oil". I replaced with 700ml of gbox oil (synthetics are based on mineral oil anyhow. buy you do you). and 'surprisingly' just as the 700ml finished going in, it started to dribble out of that blank plug. Whine gone, gbox smooth inc 1st.
Dangerous/Caution part is gbox needs to be warm/hot to drain & will make a mess. Check drain bolt tightness while cold, just nipped up, warm gbox, then put Ali foil over exhaust, bend into funnel, & spread over garage floor, or use container.
Not sure if above helps.
I've not changed diff oil yet but did chk level.
That must be at a specific angle. Be sure to search the forum before you attempt to adjust there.
Any idea what page/section this was in? I cant find anything in the Service manual addressing anything on the trans, actually.Following the handbook or w/shop manual (can’t recall offhand) I did a full clutch adjustment, starting at the gearbox end.
I checked a few, the 85TT manual has the same section as the V7 manual, and I didn't find specific instruction (unless the 'check that the cable lug turns freely' is the instruction) in the 85 vehicle manual 2Q000400, the 2Q000383 engine manual (E4, but same mechanically) or the V9 2Q000202 (which I think is the 6spd version).The V85TT manual or any with 6pd trans. Search for one says "Moteur"
Any idea what page/section this was in? I cant find anything in the Service manual addressing anything on the trans, actually.